A forum for owners of Yamaha TTR250 trail and enduro bikes!

Members Login
Username 
 
Password 
    Remember Me  
Post Info TOPIC: Battery


Veteran Member

Status: Offline
Posts: 33
Date:
COULD IT BE THE BATTERY??
Permalink  
 


Having recently purchased my TTR, I was told that the battery was new. It is stamp dated May 2011. The bike started fine and turned over quickly. The other day I noticed that the swinging arm appeared to have a corrosive substance on it and further investigation revealed that it was coming from the battery compartment. The battery, a GUYUE is sealed, but I believe that it has leaked. I have charged the battery and my Oxford bike charger shows that it has a full charge of 12.3 volt. However when I now turn the bike over, it turns over very slow, but increases slightly. Both brake light and head light work. Having attempted to start the bike I took the battery off and it showed that the volts had gone down.  Even though it shows a full charge after charge, could it still be a faulty battery or could it be something else. Any suggestions would be greatfull. crycrycry  



__________________


Super Guru

Status: Offline
Posts: 8557
Date:
Permalink  
 

I can't think of anywhere else that would leak acid so I think you have to accept the fact that the battery is leaking and will need replacing before any more acid damage is done Mike cry

I know pre-Christmas is not a good time to be spending out.

Best source for new batteries I have found is just up the road from me so I don't have to pay p&p wink

See http://ttr250.activeboard.com/t45151003/ttr-batteries/

Brian



__________________

Exeter, Devon, UK

http://www.ttr250.com  - The one and only dedicated TTR250 FAQ! 
 

TIP: For easy viewing bookmark the "Recent Posts" view - http://ttr250.activeboard.com/p/recent/ 



Veteran Member

Status: Offline
Posts: 33
Date:
Permalink  
 

I thought as much but I had to ask just in case, but it does seem strange that the battery voltage is high and it still won't turn the bike over fast enough. Thankyou for your help Brian, I will have to invest in a replacement.



__________________


Veteran Member

Status: Offline
Posts: 66
Date:
Permalink  
 

Stick the voltmeter on it and press the starter, i'm betting the cranking voltage will be 4 - 5v .



__________________

I'm pink, therefore i'm spam



Veteran Member

Status: Offline
Posts: 33
Date:
Permalink  
 

Thanks, I will see if I can borrow one and give it a go.

Mick



__________________


Super Guru

Status: Offline
Posts: 8557
Date:
Permalink  
 

Logi wrote:

Stick the voltmeter on it and press the starter, i'm betting the cranking voltage will be 4 - 5v .


 I am guessing that is bad?



__________________

Exeter, Devon, UK

http://www.ttr250.com  - The one and only dedicated TTR250 FAQ! 
 

TIP: For easy viewing bookmark the "Recent Posts" view - http://ttr250.activeboard.com/p/recent/ 



Veteran Member

Status: Offline
Posts: 33
Date:
Permalink  
 

Do you mean the cranking voltage would be bad if it was 4-5 volt?

I will let you know when I have managed to get a meter. 



__________________


Veteran Member

Status: Offline
Posts: 33
Date:
Permalink  
 

Logi you were right cranking voltage as low as 5, no wonder it won't turn over. I have found that the battery was leaking from the press on top, which is meant to be a sealed unit. Thasnks for the help. Mick  



__________________


Veteran Member

Status: Offline
Posts: 33
Date:
Permalink  
 

Logi was right, the cranking voltage was as low as 5, no wonder it wouldn't start. I have managed to source a Numax YT7B-4 from a company off Ebay called 'Batterybayuk' and with delivery it stands  me at £26.94. It will be with me on Monday, as I rang them direct to make sure I caught todays post.biggrin  



__________________


Super Guru

Status: Offline
Posts: 8557
Date:
Permalink  
 

Mickyb wrote:

Logi was right, the cranking voltage was as low as 5, no wonder it wouldn't start. I have managed to source a Numax YT7B-4 from a company off Ebay called 'Batterybayuk' and with delivery it stands  me at £26.94. It will be with me on Monday, as I rang them direct to make sure I caught todays post.biggrin  


http://www.ebay.co.uk/itm/NUMAX-YT7B-4-CT7B-4-GEL-MOTORCYCLE-BATTERY-/150849178444?pt=UK_Motorcycle_Parts&hash=item231f4fcb4c&_uhb=1

Now that is a bargain!!!!!



__________________

Exeter, Devon, UK

http://www.ttr250.com  - The one and only dedicated TTR250 FAQ! 
 

TIP: For easy viewing bookmark the "Recent Posts" view - http://ttr250.activeboard.com/p/recent/ 



Senior Member

Status: Offline
Posts: 299
Date:
Battery information - super thread!
Permalink  
 


Had my battery on charge for the ttr and put it back after 2 goes of the starter it went flat.

 

whats the best way to bump start a ttr

 

Thanks



__________________


Super Guru

Status: Offline
Posts: 2608
Date:
RE: TTR Battery
Permalink  
 


Firstly - get it to the top of a hill.

Secondly - face the bike downhill and put it in second gear.

Thirdly - heave the bike, in gear, backwards. This turns the engine backwards until the piston is at the top of the stroke.

Fourthly - Ignition on, if engine cold give it a bit of choke, petrol tap on then push or roll the bike downhill with clutch disengaged but still in second gear.

Fifthly - when you are free-wheeling at a decent lick ease the clutch out fully. Momentum will turn the engine over quickly enough to start it running.

If it doesn't work disbelief then push it back up the hill and try again.

Best bet is to get a new battery if yours is not holding its charge.  confuse

TTR battery (Numax YT7B-4) from Positive Batteries do a quick turnaround at a competitive price.

Martyn



__________________

You're never too old to learn something stupid

East Budleigh. Devon



Senior Member

Status: Offline
Posts: 299
Date:
Permalink  
 

Thank you, I was trying it in first and just lock rear wheel when let clutch out, It is supposed to be a new battery in it I will charge it again and if that dont work bump it, wonder why yamaha never fitted a kick start as main competion of the time was suzuki dr 250 and 350, kawasaki klr 250 and honda xr250 which all had kick start and some both.

really want to find a kick start for it I normaly never buy a bike with out a kick start.

Are the polisport head lights on total ttr any good and road legal

__________________


Super Guru

Status: Offline
Posts: 8557
Date:
Permalink  
 

A kickstart option was available on the metal-tanked TTRs and I have had quite a few go through TTR Towers with them fitted. All blue plastic-tanked TTRs have dual start.

I occasionally get a kickstart kit when I break a "blue" TTR engine for spares. Very easy to fit - see http://ttr250.com/TTR_retrofitting_kickstart.htm

The Polisport headlights are defintely road legal in the UK.

I hope your battery is OK. Sounds odd though.

Brian



__________________

Exeter, Devon, UK

http://www.ttr250.com  - The one and only dedicated TTR250 FAQ! 
 

TIP: For easy viewing bookmark the "Recent Posts" view - http://ttr250.activeboard.com/p/recent/ 



Senior Member

Status: Offline
Posts: 299
Date:
Permalink  
 

ttr fan could you message me at (saharvey@hotmail.co.uk) when you get a kick start kit in, as i would be intrested in getting one asap,

dont like the head light i got on as not very secure and only got one bracket on each side and move arounds abit.

abit odd about battery, doesnt help that head light comes on straight away when you turn ignition on as that zaps abit of power.

might have to order one of those polisports units.

__________________


Super Guru

Status: Offline
Posts: 8557
Date:
Permalink  
 

sammyttr wrote:

ttr fan could you message me at (saharvey@hotmail.co.uk) when you get a kick start kit in, as i would be intrested in getting one asap,

dont like the head light i got on as not very secure and only got one bracket on each side and move arounds abit.

abit odd about battery, doesnt help that head light comes on straight away when you turn ignition on as that zaps abit of power.

might have to order one of those polisports units.


You are on the waiting list for a kickstart kit!

The easiest way to save the battery is to cut into the dip wire (yellow I think) when you fit your new headlight and put in a switch such as this one - http://www.ttr250.com/TTR_extras/#light_switch 

The headlight always on is a safety plus though...

Brian



__________________

Exeter, Devon, UK

http://www.ttr250.com  - The one and only dedicated TTR250 FAQ! 
 

TIP: For easy viewing bookmark the "Recent Posts" view - http://ttr250.activeboard.com/p/recent/ 



Member

Status: Offline
Posts: 18
Date:
Permalink  
 

''abit odd about battery, doesnt help that head light comes on straight away when you turn ignition on as that zaps abit of power.''

 

You could just pull the low beam spade terminal off the bulb  so that lights are off when the ignition is on. You still have the high beam connected when you want lights. Most bikes ride with the high beam on anyway.

The battery doesn't like going flat,  best to keep an 'optimiser' charger plugged in when garaged. Even a new battery if left to go flat won't hold its charge as well next time its charged up. I would buy a new one as its always going to be a worry when you haven't got a kickstart backup. 



__________________


Super Guru

Status: Offline
Posts: 8557
Date:
Best Battery performance?
Permalink  
 


I run a Numax on my 325 and it peforms well with the additional load - good deal on eBay here

Brian



__________________

Exeter, Devon, UK

http://www.ttr250.com  - The one and only dedicated TTR250 FAQ! 
 

TIP: For easy viewing bookmark the "Recent Posts" view - http://ttr250.activeboard.com/p/recent/ 



Veteran Member

Status: Offline
Posts: 85
Date:
Permalink  
 

Hi All,

I put the TTR project battery on charge last night and it is dead. Doesnt even register on the charger so will need to replace it.

This one is a motobatt and to be honest it 'looks' new unless it was steam cleaned while the rest of the bike was left with a layer of dirt everywhere else

Before I head off and order any old battery, which battery would you recommend as tried and tested? 

Mine is a 93 OE with only the lecky start.

cheers

Ian



__________________


Senior Member

Status: Offline
Posts: 235
Date:
Permalink  
 

Would that suit a 94 raid? Mine is dead as a dodo...

__________________

Pete Brown

Keighley, West Yorkshire

'94 Yamaha TTR 250 Raid (with Open Enduro headlight, grrr...)

'54 plate Suzuki GSF 650S (Bandit)

Previously Yamaha YBR125, Yamaha TY125, Yamaha TY250



Super Guru

Status: Offline
Posts: 8557
Date:
Permalink  
 

Yep - fits all models!



__________________

Exeter, Devon, UK

http://www.ttr250.com  - The one and only dedicated TTR250 FAQ! 
 

TIP: For easy viewing bookmark the "Recent Posts" view - http://ttr250.activeboard.com/p/recent/ 



Guru

Status: Offline
Posts: 932
Date:
Permalink  
 

I'm using a Motobatt battery now & it seems like it has heaps of go. Lasts ages cranking & plenty of power. We will see how long all those good things last wink

...........................

Jarrah.



__________________

YAMAHA ROCKS!!!!!!

TTR250ACTIVE''BORED'' ADDICT!

Favourite quote: To be old & wise first you must be young & dumb!

My own: Your never too young to learn an old trick! :)



Veteran Member

Status: Offline
Posts: 85
Date:
Permalink  
 

I ordered 2 Numax batteries from the Ebay store Brian mentioned but ended up with a Varta battery for my CRF250X and a dynavolt for the TTR so I wont be able to give any feedback on this sorry.

Not complaining about the replacements as both of these batteries are double the price of the numax versions!



__________________


Veteran Member

Status: Offline
Posts: 85
Date:
Advice needed on trickle battery charge.
Permalink  
 


Buy a low ampere solar panel, Thats what trickle charges my triumph thunderbird over the winter,works a treat but make sure its low amp otherwise you might boil your battery.

Look for something 1-1.5 w,no higher if you can get one less than 1 w even better,somewhere on the web is a formula for working out the correct charge rate according to your battery amp hours.

Mines actually 1.5 w but it only kicks that out on really sunny days, the uk is not sunny most of the time and therefore I get away with it as the charger is usually putting out less than the max.



-- Edited by Andy_C on Sunday 22nd of September 2013 10:45:13 PM



-- Edited by Andy_C on Sunday 22nd of September 2013 10:46:05 PM



-- Edited by Andy_C on Monday 23rd of September 2013 06:19:18 PM

__________________


Guru

Status: Offline
Posts: 599
Date:
Permalink  
 

i have a fully charged 12 volt car battery removed from the vehical. If i were to remove the TTR battery and connect the  

postive to positive and negative to negative ( like a jump start ) but both batterys  out of the machines. would it work as a trickle charge over night  topping the TTR  battery and keeping it healthy.  



__________________

 Tweed heads Australia. 



Super Guru

Status: Offline
Posts: 8557
Date:
Permalink  
 

Markvan wrote:

i have a fully charged 12 volt car battery removed from the vehical. If i were to remove the TTR battery and connect the  

postive to positive and negative to negative ( like a jump start ) but both batterys  out of the machines. would it work as a trickle charge over night  topping the TTR  battery and keeping it healthy.  


I did A Level physics at school which included a lot of electrickery stuff but I have forgotten more than I ever learnt!

Thinking about your question, I don't think anything would happen as the TTR battery isn't going to draw current from the car battery - all will be at rest surely?

Brian 



__________________

Exeter, Devon, UK

http://www.ttr250.com  - The one and only dedicated TTR250 FAQ! 
 

TIP: For easy viewing bookmark the "Recent Posts" view - http://ttr250.activeboard.com/p/recent/ 



Guru

Status: Offline
Posts: 599
Date:
Permalink  
 

TTR. Battery now is 12.4 volt on multi meter. I cant atart the bike for another 3 months.  Car battery is fully charged on 12.8 volt. I thought they may have evened them selfs out with say 12.6 in each.  Damage to the TTR battery is my main worry. I will test it in the next few days and see what happens. 



__________________

 Tweed heads Australia. 



Veteran Member

Status: Offline
Posts: 78
Date:
Battery
Permalink  
 


hi can anyone help me i was stripping my bike down today and cleaning it. when i noticed the battery negitave was going to the red wire at the top and the positave was going to the bottom look at the pic attach is this the wrong battery, and if it is wrong will it of done any damage.         thanks paul  blankstare



-- Edited by pauls ttr on Sunday 26th of January 2014 08:24:28 PM

Attachments
__________________

 

 

west yorkshire 



Veteran Member

Status: Offline
Posts: 34
Date:
Permalink  
 

without looking at mine,and going by the orientation of the battery bolts in relation to the wires,all looks ok,you could follow the lower wire and see if it goes to solenoid to put your mind at ease.

solenoid wire is the shiny black thing to the right on your pics



__________________


Super Guru

Status: Offline
Posts: 8557
Date:
Permalink  
 

The conventional way to mount a TTR battery is with the positive terminal at the top attached to the red wire.

battery.jpg



__________________

Exeter, Devon, UK

http://www.ttr250.com  - The one and only dedicated TTR250 FAQ! 
 

TIP: For easy viewing bookmark the "Recent Posts" view - http://ttr250.activeboard.com/p/recent/ 



Veteran Member

Status: Offline
Posts: 78
Date:
Permalink  
 

i thought it was the wrong battery will it of damage any thing thanks paul



__________________

 

 

west yorkshire 



Veteran Member

Status: Offline
Posts: 78
Date:
Permalink  
 

whats the code for the right battery please



__________________

 

 

west yorkshire 



Super Guru

Status: Offline
Posts: 8557
Date:
Permalink  
 

Info on batteries here

Did your TTR start and run OK with the battery like that?

Could the polarity of the battery have been reversed in some way confuse



__________________

Exeter, Devon, UK

http://www.ttr250.com  - The one and only dedicated TTR250 FAQ! 
 

TIP: For easy viewing bookmark the "Recent Posts" view - http://ttr250.activeboard.com/p/recent/ 



Veteran Member

Status: Offline
Posts: 78
Date:
Permalink  
 

i only started it once when i bought it, it started ok and runs fine. what do you mean Could the polarity of the battery have been reversed in some way. wat does the red and black wire go to thanks paul



__________________

 

 

west yorkshire 



Super Guru

Status: Offline
Posts: 8557
Date:
Permalink  
 

Red to battery +ve and black to battery -ve  ....   normally!



__________________

Exeter, Devon, UK

http://www.ttr250.com  - The one and only dedicated TTR250 FAQ! 
 

TIP: For easy viewing bookmark the "Recent Posts" view - http://ttr250.activeboard.com/p/recent/ 



Super Guru

Status: Offline
Posts: 8557
Date:
Permalink  
 

Hi Paul

The pic below shows where the battery leads go on the solenoid.

Solenoid wires.jpg

 

This looks to be a good deal on a battery. You can check the dimensions against your battery.

I hope that helps?

Brian



__________________

Exeter, Devon, UK

http://www.ttr250.com  - The one and only dedicated TTR250 FAQ! 
 

TIP: For easy viewing bookmark the "Recent Posts" view - http://ttr250.activeboard.com/p/recent/ 



Veteran Member

Status: Offline
Posts: 78
Date:
Permalink  
 

Sorted it now. I have a new battery and fires up nice thankyou


__________________

 

 

west yorkshire 



Veteran Member

Status: Offline
Posts: 43
Date:
Battery & kickstart
Permalink  
 


Hi could anyone recommend a decent battery at a decent price to fit my TTR250 ENDURO also would it be a good idea to fit a kick start to my bike.



__________________


Super Guru

Status: Offline
Posts: 2608
Date:
Permalink  
 

Numax YT7B4 are usually a good choice. wink

CLICK HERE for a UK eBay page.

However, there will be other suppliers and probably cheaper suppliers too! confuse

Martyn

 



__________________

You're never too old to learn something stupid

East Budleigh. Devon



Super Guru

Status: Offline
Posts: 1324
Date:
Permalink  
 

If you want to go cheap, I'd recommend a Motobatt. I have had one for a year or more now and all is still A1. You can find these batteries on eBay for around $55.00- http://www.ebay.com.au/itm/DRY-CELL-DRZ400-SUZUKI-YAMAHA-TTR250-BATTERY-USA-AGM-12V-MOTORCYCLE-YT7BBS-/251372461131?pt=AU_Motorcycle_Parts_Accessories&hash=item3a86f75c4b

Fitting a kickstarter would be a great idea but realistically will probably never happen as they are not available from Yamaha anymore TTBOMK. There are a few kits online that I saw for around $450.00 AUD but at that price it is not worth it, although it seems to be the going price for them.

Jarrah



__________________

2000 TT-R250M-

Spoiler



Veteran Member

Status: Offline
Posts: 53
Date:
Permalink  
 

now you know it is a YT7B4 it may be worth a quick call to your local spares shop.

__________________


Veteran Member

Status: Offline
Posts: 44
Date:
Battery Dead Or Not Dead???
Permalink  
 


Hi there all, I would like some opinions to confirm what I think? hmm

So my lovely TTR starts first time every time on the kick, but trying the starter button just struggles to turn. So I did some checks this is what I found...

  1. Bike running more than enough voltage and stable going to battery - 13 volts ish
  2. Bike stopped ignition off - 12 volts ish on battery
  3. Turn ignition on and voltage drops to 8.3 volts straight away before pressing anything
  4. Press starter and voltage drops to 6 and then returns to 8
  5. Ignition off only 9 volts left now

I would say that the battery is dead on this testing.. Why would a drop from over 12 to 8 happen straight after switch on??

Surely 8 volts is not enough to turn over the bike?

Any advise or ideas from you helpful people on here would be great..

Cheers

Danny biggrin 

PS Horn does not buzz at 9 volts LOL smile

 

 



__________________


Super Guru

Status: Offline
Posts: 2608
Date:
Permalink  
 

Danny, that cerainly sounds a dying battery to me. hmm

Obviously the generator must be working for the thing to be showing 13v when running. confuse

If it has no short in the circuit then it's logical to presume a dead/dying cell or cells. confuseconfuse

For the layout of a few £s or $s try a substitute (new) battery. smile

Martyn



__________________

You're never too old to learn something stupid

East Budleigh. Devon



Veteran Member

Status: Offline
Posts: 44
Date:
Permalink  
 

That's great glad my 💭 is going in right direction


__________________


Super Guru

Status: Offline
Posts: 1481
Date:
Permalink  
 

sounds like the battery . your check on charging sounds ok .

you have done a load test be it a smallish load which the batt should handle .so most likley the battry has failed .

ive done 14 years as an auto elec in a previous life .and you have done a good basic diagnosis .

 



__________________


Veteran Member

Status: Offline
Posts: 44
Date:
Permalink  
 

Thank you..Now the million dollar 💲 question. Recommendations on a good battery 🔋?

__________________


Super Guru

Status: Offline
Posts: 2608
Date:
Permalink  
 

Depends where you are based. confuse

A location, town, country or continent would help. wink

Martyn



__________________

You're never too old to learn something stupid

East Budleigh. Devon



Veteran Member

Status: Offline
Posts: 44
Date:
Permalink  
 

Arh yes sorry UK Based, Hampshire...

__________________


Super Guru

Status: Offline
Posts: 8557
Date:
Permalink  
 

The Numax or Lucas gel batteries on eBay are less than £30 inc carriage - not had any problems with either type biggrin



__________________

Exeter, Devon, UK

http://www.ttr250.com  - The one and only dedicated TTR250 FAQ! 
 

TIP: For easy viewing bookmark the "Recent Posts" view - http://ttr250.activeboard.com/p/recent/ 



Guru

Status: Offline
Posts: 599
Date:
Battery life span
Permalink  
 


image.jpg

Ive had a good run out of the orginal yamaha battery. Its a 2007 auzzy model and i guess the battery came with the bike from Japan in 2007. Im gunna try and get to 2017 before i replace it. ( only joking) but it is 7 or 8 years old. Winter here in Auzzyland maybe its close to its last legs. Time will tell. Bike still starts easy so far. Wonder if anyone has a battery that has lasted many years.



Attachments
__________________

 Tweed heads Australia. 

1 2  >  Last»  | Page of 2  sorted by
 
Quick Reply

Please log in to post quick replies.



Create your own FREE Forum
Report Abuse
Powered by ActiveBoard